Effect of Infrared Roasting Process on the Microorganism Contaminations of Long and Round Iranian Pistachio Kernels

Journal of Nuts

مقاله 3، دوره 11، شماره 1، خرداد 2020، صفحه 23-36   

نوع مقاله: Research Article

شناسه دیجیتال (DOI): 10.22034/jon.2020.1869504.1057

نویسندگان

Afsaneh Morshedi؛ Seyed Mohammad Ali Razavi^*

Department of Food Science and Technology, Ferdowsi University of Mashhad (FUM), POBox: 91775-1163, Mashhad, Iran

چکیده

In this paper, the effect of infrared (IR) roasting conditions on Aflatoxins and total counts of two types of Iranian pistachio kernels, long and round, was studied. The optimized roasting conditions, 70 V for round pistachios and 90 V for long pistachios with 10 cm distance from IR source were used. Naturally Aflatoxin-contaminated kernels were supplied and roasted. Microbiological and Aflatoxins tests were done before and after roasting, and the results were analyzed by t-test at 5% confidence level. It was shown that 64.00% of total Aflatoxins and 63.99% of Aflatoxin B₁ were reduced in long roasted pistachio nut kernels after IR-roasting. However, the reduction levels were 71.40% and 64.94% for total Aflatoxins and Aflatoxin B₁ in round pistachio kernels, respectively. Total counts reduction was 99.99% in the round and 99.97% in the long pistachio kernels. In addition, mold and yeast numbers were reduced 99.99% in the round and 99.97% in the long pistachio kernels. Considering mild conditions (90^°C and 11.5 min) in IR-roasting process, considerable amounts of reduction in bacteria, mold, and yeast, and the most important reduction of Aflatoxins. This research has shown that IR-roasting process can be considered as an effective method for pistachio nut roasting in Aflatoxin contamination reduction.

کلیدواژه‌ها

Aflatoxin؛ Infrared؛ Microbial contamination؛ Pistachio kernel؛ Roasting

مراجع

Association of Official Analytical Chemists, (1990) Official Methods of Analysis, 15^th ed. AOAC, Arlington, VA.

Afolabi CG, Ezekiel CN, Kehinde IA, Olaolu AW, Ogunsanya OM (2015) Contamination of Groundnut in south-western Nigeria by Aflatoxigenic fungi and Aflatoxin in relation to processing. Phytopathology. 163(4), 279-286.

American Public Health Association, (1984) Compendium of methods for microbiological examination of foods, 2^nd ed., APHA, Washington, DC.

Atangulu GG, Pan Z (2011) Infrared radiative properties of food materials, New York, CRC Press, 231-245 

Arzandeh S, Jinap S (2011) Effect of initial Aflatoxin concentration heating time and roasting on Aflatoxin reduction in contaminated peanuts and process optimization using response surface modeling. International Journal of Food Science and Technology. 46, 485-491.

Bashiri P, Hadad Khodaparast MH, Sedaghat N, Tabatabaei F, Nasiri Mahallati M (2013) Effect of aqueous ozone on Aflatoxin degradation in pistachio of Ohadi cultivar, Iranian Food Science and Technology Research Journal. 9(3), 215-221.

Bullerman LB, Bianchini A (2007) Stability of mycotoxins during food processing, International Journal of Food Microbiology. 119, 140-146.

Doster MA, Michailides TJ (1995) The development of early split pistachio nuts and the contamination by molds, Aflatoxins and insects, First International Symposium on Pistachio Nut, 20-24 September 1994, Adana, Turkey-Acta Horticulture. 419, 359-364.

De Mello FR, Scussel VM (2009) Development of physical and Optical methods for in-shell brazil nuts sorting and Aflatoxin Reduction. Journal of Agricultural Science. 1(2), 3- 15.

Emami A, Suzangar M, Barnett R (1977) Contamination of pistachio nuts with Aflatoxin while on the trees and in storage Zesty problem owe post pow Nauk Rolniczych. 189, 135-140.

FAO (Food and Agriculture Organization), FAOSTAT Database Results, (2017) <http://faostat.fao.org/site/339/default.aspx>.

Goktas Seyhan F (2003) Effect of soaking and salting and moisture uptake of pistachio nut (Pistachia Vera L.) from Turkey. GIDA. 28(4), 395-400.

Hojjati M, Calin-Sanchez A, Razavi SH, Carbonell-Barrachina AA (2013) Effect of roasting on color and volatile composition of pistachio (Pistacia Vera L.). International Journal of Food Science and Technology. 48, 437-443. 

Jun SK, Krishnamurthy K, Irudayaraj JD (2011) Fundamentals and theory of infrared radiation, New York: CRC Press. 431-458.

www.iranpistachio.org /fa /secretariat.

www.ISIRI.org, No: 218, 1375."Pistachio, Moisture Analysis Method".

www.ISIRI.org, No: 5272, 1393."Microbiological Analysis, total counts"

www.ISIRI.org,  No: 10899, 1387."Microbiological Analysis, mold & yeast counts"

www.ISIRI.org, No: 6872, 1390."Aflatoxin measurement (B & G), by Immune affinity column"

Kashaninejad M, Mortazavi A, Seifkordi A, Tabil LG (2005)  Some physical properties of pistachio (Pistachia Vera L.) nut and its Kernel. Journal of Food Engineering. 72(1), 30-38.

Kashaninejad M, Kashiri M (2007) Hydration kinetics and changes in some physical proper  ties of wheat kernels. Iranian Food Science & Technology Research Journal. 2(3), 47-59.

Krishnamurthy K, Khurana HK, Jun S, Irudayaraj J, Demirci A (2008) Infrared heating in food processing: an overview,Comprehensive Reviews in Food Science and Food Safety. 7, 2-13

 Lee LS, Cucullu AF, Franz AO, Pons WA (1969) Destruction of Aflatoxin in peanuts during dry and oil roasting. Journal of Agricultural Food Chemistry. 17(3), 451-453.

Mahbobinejhad Z, Aminian H, Ebrahimi L, Vahdati K (2019) Reduction of Aflatoxin production by exposing Aspergillus flavus to CO2. Journal of Crop Protection. 8(4), 441-448.

Mazaheri M (2012) Effect of UV radiation on different concentrations of Aflatoxin B1 in pistachio, Acta Horticulture 963: 51-69.

Me'ndez-Albores A, Campos-Aguilar AZ, Moreno-Martinez E, Vazquez Duran  A  (2013) Physical and chemical degradation of B-Aflatoxin during the roasting and ditching of cocoa liquor. Journal of Agricultural Science Technology. 15, 557567.

Me'ndez-Albores A, Martinez-Bustos F, Gaytan-Martinez V, Moreno-Martinez E (2008) Effect of lactic acid and citric acid on the stability of B- Aflatoxins in extrusion-cooked sorghum. Applied Microbiology. 47, 1-7.

Mohammadi Moghaddam T (2014) Evaluation of roasted pistachio nuts' quality using process analytical tools: Experimental and Modeling study, PhD Dissertation, Ferdowsi University of Mashhad, Iran. 

Mojtahedi H, Rabie CJ, Lubben A, Steyn M, Danesh D (1979) Toxic Aspergillus from pistachio nuts, Mycopathologia. 11, 24-37. 

Mojtahedi H, Danesh V, Haghighi B, Barnet R (1978) Postharvest pathology and mycotoxin contamination of Iranian pistachio nuts. Phytopathology. 68, 1800-1804.

Morshedi A, Razavi SMA, Kashaninejad M, Shaker Ardekani A, Mostafavi A (2018) Optimization of Infrared roasting process of Iranian pistachio kernels cultivars by RSM. Modern Food Technologies. In Press.

Morshedi A (2018) optimization of infra-red roasting process of Iranian pistachio kernel cultivars by RSM, Ph.D. Thesis.

Nazari Galedar M, Mohtasebi SS, Tabatabaeefar A, Jafari A, Fadaei H (2010) Moisture dependent geometeric and mechanical properties of wild pistachio (Pistachia vera L.) nut and kerne. International  Journal of Food Properties. 13, 1323-1338.

Nazari Galedar M, Mohtasebi SS, Tabatabaeefar A, Jafari A (2008) Physical properties of wild pistachio (Pistachia Vera L.) nut and its kernelas a function of moisture content. International Agrophysics. 22, 117-124.

Nimol C, Devahastin S (2011) Vacuum infrared drying, New York, CRC Press, 512-525.

Norozi, M., ValizadehKaji, B., Karimi, R., Nikoogoftar Sedghi, M. (2019). Effects of foliar application of potassium and zinc on pistachio (Pistacia vera L.) fruit yield. International Journal of Horticultural Science and Technology, 6(1), 113-123.

Ozdemir M (2001) Mathematical analysis of color changes and chemical parameters of roasted hazelnuts, PhD Thesis.  

Ozkan G, Koyuncu MA (2005) Physical and composition of some walnut (Juglans regia L.,) genotypes grown in Turkey. Grasas Y Aceites. 56(2), 141-146.

Pearson TC, Schatzki FT (1998) Machine vision system for automated detection of Aflatoxin-contaminated pistachios. Journal of Agricultural and Food Chemistry. 46, 2248-2252.

Polat R, Aydin C, Eral AB (2007) Some physical and mechanical properties of  pistachio nut. Bulgarian Journal of Agricultural Science. 13, 237-246.

Porshokouhi MGH, Mohammadi ShM,Mohseni SH, Kermani AM, Abdolalizade E (2014) Some physical properties of pistachio and pistachio kernel(Ghazvin cultivars).Food Technology & Nutrition.3,49-51. 

Razavi SMA., Emadzadeh B, Rafe A, Mohammad Amini A (2007 I) The physical properties of pistachio nut and its kernel as a function of moisture content and variety: Part I., Geometerical properties, Journal of Food Engineering. 81(1), 209-217.

Razavi SMA, Rafe A, Mohammadi Moghaddam T, Mohammad Amini A (2007 II) Physical properties of pistachio nut and its kernel as a function of moisture content and variety: Part II., Gravimeterical properties. Journal of Food Engineering. 81(1), 218-225.

Razavi SMA, Mohammad Amini A, Rafe A, Emadzadeh B (2007 III) The Physical properties of pistachio nut and its kernel as a function of moisture content and variety: Part III., Frictional properties. Journal of Food Engineering. 81(1), 226-235.

Razavi SMA, Mazaherinasab M, Nickfar F, Sanaeefard H (2008) Physical properties and image analysis of wild pistachio nut (Baneh). Iranian Food science & Technology Research Journal. 3(2), 61-71.   

Rastegar H, Shoeibi Sh, Yazdanpanah H,  Amirahmadi M, Mousavi Khaneghah A,  Campangollo FB,  Sant Ana ADS, (2016) Removal of Aflatoxin B1 by roasting with lemon juice and/or citric acid in contaminated pistachio nuts. Food Control. 6, 4-25.

Schatzki TF, Pan J (1997) Aflatoxin distribution in small pistachios. Journal of Agricultural Food Chemistry. 45, 205-207.

Scudamore KA, Patel S (2008) fate of deoxynivalenol and fumonisins in wheat and maize during commercial breakfast cereal production. World Mycotoxin Journal. 1(4), 437-448.

Soliman KM (2002) Incidence, level, and behavior of Aflatoxins during coffee bean roasting and decaffeination. Journal of Agricultural Food Chemistry. 50(25), 74777481. 

Sommer NF, Buchanan TR, Fortge RJ (1988) Relation of early splitting and tattering of pistachio nuts to Aflatoxin in the orchard. Phytopathology. 76(7), 692-694.

Thomson SV, Mehdy MC (1978) Occurrence of Aspergillus flavous in pistachio nuts prior to harvest. Phytopathology. 68, 1112-1114.

Uysal N, Sumnu G, Sahin S,. (2009) Optimization of Microwave- Infrared Roasting of hazelnut. Journal of Food Engineering.90, 261-255.

WWW.IPU.org

Yang J, Bingol G, Pan Z,  McHugh MT (2010. Infrared heating for dry-roasting and pasteurization of almonds. Journal of Food Engineering. 101, 273-280.

Yang J, Pan Z, Takeoka G, Mackey B, Bingol G, Brandl MT,  McHugh TW (2013) Shelf-life of infrared dry-roasted almonds. Food Chemistry. 138, 371-378.

Yazdanpanah H, Mohammadi T, Abouhossain G, Cheraghali AM (2005) Effect of Roasting on Degradation of Aflatoxins in contaminated pistachio nuts. Food and Chemical Toxicology. 43, 1135-1139.

Zivoli R, Gambacorta L, Perrone G, Solfrizzo M (2014) Effect of almond processing on levels and distribution of Aflatoxin in finished products and byproducts. Journal of Agricultural Food Chemistry. 62(24), 5707-5715.