Effectiveness of Sequential Pre-treatment and Application of High-porosity Hybrid Fly Ash Geopolymer/alginate Adsorbent for the Treatment of Batik Wastewater

Journal of Chemical Health Risks

دوره 11، شماره 4، اسفند 2021، صفحه 345-356   

شناسه دیجیتال (DOI): 10.22034/jchr.2021.682249

نویسندگان

Siti Mazatul Azwa Saiyed Mohd Nurddin¹؛ Suriati Sufian^{* 2}؛ Zakaria Man¹؛ Nurul Ekmi Rabat¹؛ Nazwin Ahmad²

¹Department of Chemical Engineering, Universiti Teknologi PETRONAS, 31260 Bandar Seri Iskandar, Perak, Malaysia

²Mineral Research Centre, Jalan Sultan Azlan Shah, 31400 Ipoh, Perak, Malaysia

چکیده

In this work, hybrid fly ash geopolymer/alginate spheres (GSA) were produced and used as an effective and economical adsorbent in a treatment of batik wastewater. A preparation of GSA adsorbent involved a facile method where the fly ash (FA) based geopolymer was entrapped into sodium alginate (SA) followed by cross-linking of Ca²⁺ and SA.  In additional to that, natural egg white was utilized as a foaming agent. Characterization of the GSA adsorbent strongly confirmed the formation of hybrid spheres that composed of geopolymer and alginate with extremely porous microstructure with porosity of 87.64%. Surface area, average pore diameter and pore volume was 12.874 m²/g, 3.3110 nm and 0.1684 cm³/g, respectively. Prior to the adsorption process, the batik wastewater was pre-treated using high concentration acid hydrofluoric (HF) and magnesium oxide (MgO). The optimum acidification pre-treatment at pH 3 removed ~ 93% of chemical oxygen demand (COD). In the subsequent stage, the highest percentage of COD removal was ~27% by utilizing 1500 mg/L of MgO powder.  In the final stage, different dosages of GSA adsorbent was used in order to treat the remaining COD and resulted in as maximum as ~67% of the COD removal. According to the finding, the sequential pre-treatment and application of high-porosity hybrid GSA adsorbent offered a great potential to be implemented as an economical and effective batik wastewater treatment.

کلیدواژه‌ها

Geopolymer/alginate؛ Batik wastewater؛ Adsorbent؛ High-porosity

مراجع

1.Desa A.L., Hairom N.H.H., Ng L.Y., Ng C.Y., Ahmad M.K., Mohammad A.W., 2019. Industrial Textile Wastewater Treatment Via Membrane Photocatalytic Reactor (MPR) In The Presence of Zno-PEG Nanoparticles and Tight Ultrafiltration. Journal of Water Process Engineering. 31, 100872.

2. Pang Y.L., Abdullah A.Z., 2013. Current Status of Textile Industry Wastewater Management And Research Progress In Malaysia: A Review. CLEAN - Soil, Air, Water. 41(8), 751-764.

3. Rashidi H., Nik Sulaiman N.M., Awanis Hashim N., Che Hassan C.R., Davazdah Emami S., 2015. Simulated Textile (Batik) Wastewater Pre-Treatment Through Application Of A Baffle Separation Tank. Desalination and Water Treatment. 57(1), 151-160.

4. Effendi H., Sari R., Hasibuan S., 2020. In 35 th Annual Conference of the International Association for Impact Assessment, AIA15 Conference Proceedings: Florence-Italy, October.

5. Natarajan T.S., Natarajan K., Bajaj H.C., Tayade R.J., 2013. Study on Identification of Leather Industry Wastewater Constituents and Its Photocatalytic Treatment. International Journal of Environmental Science and Technology. 10(4), 855-864.

6. Khalik W.F.W.M., Ho L.N., Ong S.A., Wong Y.S., Yusoff N.A., Ridwan F., 2015. Decolorization and Mineralization Of Batik Wastewater Through Solar Photocatalytic Process. Sains Malaysiana. 44(4), 607-612.

7. Mukimin A., Vistanty H., Zen N., Purwanto A., Wicaksono K.A., 2018. Performance of Bioequalization-Electrocatalytic Integrated Method for Pollutants Removal of Hand-Drawn Batik Wastewater. Journal of Water Process Engineering. 21, 77-83.

8. Suteu D., Zaharia C., Măluțan T., 2012. Biosorbents Based on Lignin Used in Biosorption Processes from Wastewater Treatment: A Review, 1st ed., Nova Science Publishers Inc.: New York. pp 279-305.

9. Sutisna, Wibowo E., Rokhmat M., Rahman D.Y., Murniati R., Khairurrijal, Abdullah M., 2017. Batik Wastewater Treatment Using TiO₂ Nanoparticles Coated on the Surface of Plastic Sheet. Procedia Engineering. 170, 78-83.

10. Natarajan S., Bajaj H.C., Tayade R.J., 2018. Recent Advances Based on The Synergetic Effect of Adsorption for Removal of Dyes from Waste Water Using Photocatalytic Process. Journal of Environmental Sciences. 65, 201-222.

11. Barbosa T.R., Foletto E.L., Dotto G.L., Jahn S.L., 2017. Preparation of Mesoporous Geopolymer Using Metakaolin And Rice Husk Ash As Synthesis Precursors And Its Use As Potential Adsorbent To Remove organic Dye From Aqueous Solutions. Ceramics International. 44(1), 416-423.

12. Novais R.M., Ascensão G.A., Tobaldi D.M., Seabra M.P., Labrincha J.A., 2018. Biomass Fly Ash Geopolymer Monoliths For Effective Methylene Blue Removal From Wastewaters. Journal of Cleaner Production. 171, 783-794.

13. Novais R.M., Carvalheiras J., Tobaldi D.M., Seabra M.P., Pullar R.C., Labrincha J.A., 2019 Synthesis of Porous Biomass Fly Ash-Based Geopolymer Spheres For Efficient Removal Of Methylene Blue From Wastewaters. Journal of Cleaner Production. 207, 350-362.

14. Birgani P.M., Ranjbar N., Che Abdullah R., Wong K.T., Lee G., Ibrahim S., Park C., Yoon Y., Jang M., 2016. An Efficient and Economical Treatment for Batik Textile Wastewater Containing High Levels of Silicate and Organic Pollutants Using A Sequential Process Of Acidification, Magnesium Oxide, And Palm Shell-Based Activated Carbon Application. Journal of Environmental Management. 184, 229-239.

15. Lau W.J., Ismail A.F., 2009. Polymeric Nanofiltration Membranes For Textile Dye Wastewater Treatment: Preparation, Performance Evaluation, Transport Modelling, and Fouling Control — A Review. Desalination. 245(1-3), 321-348.

16. Harif T., Khai M., Adin A., 2012. Electrocoagulation Versus Chemical Coagulation: Coagulation/Flocculation Mechanisms And Resulting Floc Characteristics. Water Research. 46(10), 3177-3188.

17. Cardoso J.C., Bessegato G., Boldrin Zanoni M.V., 2016. Efficiency Comparison of Ozonation, Photolysis, Photocatalysis and Photoelectrocatalysis Methods In Real Textile Wastewater Decolorization. Water Research. 98, 39-46.

18. Soni H., Nirmal Kumar J.I., Patel K., Kumar R.N., 2015. Photocatalytic Decoloration of Three Commercial Dyes In Aqueous Phase And Industrial Effluents Using TiO₂nanoparticles. Desalination and Water Treatment. 57(14), 6355-6364.

19. Souza R.P., Freitas T.K.F.S., Domingues F.S., Pezoti O., Ambrosio E., Ferrari-Lima A.M., Garcia J.C., 2016. Photocatalytic Activity Of Tio2, Zno And Nb2o5 Applied To Degradation Of Textile Wastewater. Journal of Photochemistry and Photobiology A: Chemistry. 329, 9-17.

20. Tong D.S., Wu C.W., Adebajo M., Jin G.C., Yu W.H., Ji S.F., Zhou C.H., 2018. Adsorption of Methylene Blue From Aqueous Solution Onto Porous Cellulose-Derived Carbon/Montmorillonite Nanocomposites. Applied Clay Science. 161, 256-264.

21. Khan M.I., Min T.K., Azizli K., Sufian S., Ullah H., Man Z., 2015. Effective Removal of Methylene Blue From Water Using Phosphoric Acid Based Geopolymers: Synthesis, Characterizations And Adsorption Studies. RSC Advances. 5(75), 61410-61420.

22. Boca Santa R.A.A., Kessler J.C., Soares C., Riella H.G., 2018. Microstructural Evaluation of Initial Dissolution of Aluminosilicate Particles And Formation Of Geopolymer Material. Particuology. 41, 101-111.

23. Ahmaruzzaman M., 2011. Industrial Wastes As Low-Cost Potential Adsorbents For The Treatment of Wastewater Laden With Heavy Metals. Advances in Colloid and Interface Science. 166(1-2), 36-59.

24. Pawar R.R., Lalhmunsiama L., Gupta P., Sawant S.Y., Shahmoradi B., Lee S., 2018. Porous Synthetic Hectorite Clay-Alginate Composite Beads For Effective Adsorption of Methylene Blue Dye From Aqueous Solution. International Journal of Biological Macromolecules. 114, 1315-1324.

25. Hussein Safauldeen S., Abu Hasan H., Sheikh Abdullah S.R., 2019. Phytoremediation Efficiency Of Water Hyacinth For Batik Textile Effluent Treatment. Journal of Ecological Engineering. 20(9), 177-187.

26. Bai C., Colombo P., 2016. High-Porosity Geopolymer Membrane Supports By Peroxide Route With The Addition Of Egg White As Surfactant. Ceramics International. 43(2), 2267-2273.

27. Xu F., Gu G., Zhang W., Wang H., Huang X., Zhu J., 2018. Pore Structure Analysis and Properties Evaluations of Fly Ash-Based Geopolymer Foams By Chemical Foaming Method. Ceramics International. 44(16), 19989-19997.

28. Yahia M.B., Torkia Y.B., Knani S., Hachicha M.A., Khalfaoui M., Lamine A.B., 2013. Models For Type VI Adsorption Isotherms From A Statistical Mechanical Formulation. Adsorption Science & Technology. 31(4), 341-357.

29. Saafie N., Samsudin M.F.R., Sufian S., Ramli R.M., 2019. Enhancement of The Activated Carbon Over Methylene Blue Removal Efficiency Via Alkali-Acid Treatment. Proceeding of the 6th International Conference on Environment (ICENV2018): Empowering Environment and Sustainable Engineering Nexus Through Green Technology, Penang, December 11-13.

30. Ge Y., Cui X., Kong Y., Li Z., He Y., Zhou Q., 2014. Porous Geopolymeric Spheres For Removal of Cu(II) From Aqueous Solution: Synthesis And Evaluation. Journal of Hazardous Materials. 283, 244-251.

31. Firdous R., Stephan D., Djobo J.N.Y., 2018. Natural Pozzolan Based Geopolymers: A Review on Mechanical, Microstructural and Durability Characteristics. Construction and Building Materials. 190, 1251-1263.

32. Nath S., Kumar S., 2019. Reaction Kinetics of Fly Ash Geopolymerization: Role of Particle Size Controlled By Using Ball Mill. Advanced Powder Technology. 30(5), 1079-1088.

33. Maleki A., Mohammad M., Emdadi Z., Asim N., Azizi M., Safaei J., 2018. Adsorbent Materials Based on A Geopolymer Paste for Dye Removal From Aqueous Solutions. Arabian Journal of Chemistry. 13(1), 3017-3025.

34. Siyal A.A., Shamsuddin M.R,, Rabat N.E., Zulfiqar M.T., Man Z., Low A., 2019. Fly Ash Based Geopolymer For The Adsorption of Anionic Surfactant From Aqueous Solution. Journal of Cleaner Production. 229, 232-243.

35. Department of Environment. Environmental Requirements: A Guide For Investors. Ministry of Natural Resources and Environment. 2010, (October), 1–78.