Characterization of composted organic solid fertilizer and fermented liquid fertilizer produced from the urban organic solid waste in Paipa, Boyacá, Colombia

International Journal of Recycling Organic Waste in Agriculture

مقاله 5، دوره 10، شماره 4، اسفند 2021، صفحه 379-395   

نوع مقاله: Original Article

شناسه دیجیتال (DOI): 10.30486/ijrowa.2021.1901014.1083

نویسندگان

José Francisco García Molano^{* 1}؛ Joel David Parra Alba¹؛ Luis Alexander Páez Guevara²

¹Facultad de Ciencias Agrarias y Ambientales, Grupo de Investigación en Abonos Orgánicos Fermentados (AOF), Tunja, Colombia

²Facultad de Ciencias Agrarias y Ambientales, Grupo de Investigación INPANTA, Tunja, Colombia

چکیده

Purpose Urban organic solid waste (UOSW) has great potential to be transformed into solid and liquid organic fertilizers, thus avoiding its accumulation in landfills and reducing the environmental impact caused by the generation of gases and leachates. Therefore, the purpose of this research was to study the management of the UOSW in the municipality of Paipa as raw material for obtaining solid organic fertilizer through composting and a liquid fertilizer through fermentation.
Method The UOSW of Paipa was combined with inorganic salts such as carbonates, phosphates, sulfates and source of carbohydrates to enrich its bacterial load and chemical composition. The content of essential nutrients that contribute to good soil-plant synergy, heavy metals and pathogenic microorganisms  in the primary and final material were determined.
Results The experiment showed a high COO load, between 24-35%, and similar values in  organic N content in the primary materials. Heavy metals were found below the minimum allowed by the CTS 5167 of 2011 for the organic solid residue, and no pathogenic microorganisms were found. Composting and fermentation processes improved the physical-chemical properties of the materials; however, the liquid mineral organic fertilizer did not comply with the established parameters, while the solid one was in compliance with the requirements.
Conclusion After a period of 4 months, the study showed that solid UOSW from the municipality of Paipa can be used as a potential source for producing organic fertilizers by adding nutrients in mineral forms, complying with the nutrient requirements for plants and soil feeding organisms.

کلیدواژه‌ها

Compost safety؛ Leachate fermentation؛ Urban organic waste؛ Fertilizer

مراجع

Álvarez J (2010) Manual de compostaje para Agricultura Ecológica. Consejería de agricultura y pesca de la Junta de Andalucía. Espain. https://doi.3140/RG.2.2.20182.24647

Azeem S (2015) Liquid fertilizer from food waste-A sustainable approach. Int Res J Environ Sci 4: 8-15

 Bello O, García F, Cuervo W (2016) Cuantificación de diazótrofos en la rizósfera del olivo (Olea europaea L.) cultivado en Boyacá, Colombia. Acta Agron 65: 109–115. https://doi.org/10.15446/acag.v65n2.44270

Bhattacharyya P, Chakrabarti K, Chakraborty A, Nayak DC, Tripathy S, Powell MA (2007) Municipal waste compost as an alternative to cattle manure for supplying potassium to lowland rice. Chemosphere 66: 1789-93. https://doi.org/10.1016/j.chemosphere.2006.07.062

Blasco M, Burbano H (2015) La vida en el suelo: Notas sobre su bioquímica y microbiología. Impresos la Castellana of Pasto, Colombia

Boucourt E, Carrasco E, López A, Rodriguez Z, Gutiérrez O (2006) Microbiota aerobia en caña fermentada con excreta vacuna como alternativa alimentaria. Revista Cubana de Ciencia Agricola 40: 279–282. https://www.redalyc.org/articulo.oa?id=193017723003

Bridgham SD, Ye R (2013) Organic matter mineralization and decomposition. In: DeLaune R.D, Reddy KR, Richardson CJ, Megonigal JP (ed) Methods in biogeochemistry of wetlands, 1st edn, SSSA Book Series, SSSAJ, USA, pp, 386-406. https://doi.org/10.2136/sssabookser10.c20

Bustamante MA, Paredes C, Marhuenda FC, Pérez A, Bernal MP, Moral R (2008) Co-composting of distillery wastes with animal manures: Carbon and nitrogen transformations in the evaluation of compost stability. Chemosphere 72: 551-7. https://doi.org/0.1016/j.chemosphere.2008.03.030

Charest MH, Antoun H, Beauchamp CJ (2004) Dynamics of water-soluble carbon substances and microbial populations during the composting of de-inking paper sludge. Bioresour  Technol 91: 53–67. https://doi.org/10.1016/S0960-8524(03)00155-X

Chelliapan S, Arumugam N, Fadhil Md  D, Kamyab H, Ebrahimi SS (2020) In: Singh L, Yousuf A, Mahapatra D (ed) Bioreactors: Sustainable design and industrial applications in mitigation of GHG emissions, 1st Edn, Elsevier, USA, 175-193. https://doi.org/10.1016/B978-0-12-821264-6.00011-5

Chen YX, Huang XD, Han ZY, Huang X, Hu B, Shi DZ, Wu WX (2010) Effects of bamboo charcoal and bamboo vinegar on nitrogen conservation and heavy metals immobility during pig manure composting. Chemosphere 78: 1177–1181. https://doi.org/10.1016/j.chemosphere.2009.12.029

Cihlář Z, Vojtová L, Conte P, Nasir S, Kučerík J (2014) Hydration and water holding properties of cross-linked lignite humic acids. Geoderma 230–231: 151–160. https://doi.org/10.1016/j.geoderma.2014.04.018

DANE (2018) Cuenta Satélite Ambiental y Económica de Flujo de Materiales - Residuos Sólidos. https://www.dane.gov.co/files/investigaciones/pib/ambientales/cuentas_ambientales/cuentas-residuos/Bt-Cuenta-residuos-2016p. Accessed 18 June 2007

Danon M, Franke-Whittle I, Insam H, Chen Y, Hadar Y (2008) Molecular analysis of bacterial community succession during prolonged compost curing. FEMS Microbiol. Ecol 65: 133–144. https://doi.org/10.1111/j.1574-6941.2008.00506.x

Domínguez J (2004) State-of-the-art and new perspectives on vermicomposting research. Earthworm Ecology 401–424. https://doi.org/10.1201/9781420039719.ch20

Elvira C, Mato S, Nogales R (1995) Changes in heavy metal extractability and organic matter fractions after vermicomposting of sludges from a paper mill industry and wastewater treatment plant. Fresenius Environ Bull 4: 503-507

Esguerra M (1989) Experiencias prácticas con biodigestores de bajo costo para la generación de energía y el tratamiento de aguas residuales en países en desarrollo. Conferencia Internacional de Mecanización Agraria. Seminario FAO-CNRE: Tecnologías de producción de biogás, Espain

Gaind S (2014) Effect of fungal consortium and animal manure amendments on phosphorus fractions of paddy-straw compost. Int Biodeterior Biodegradation 94: 90-97. https://doi.org/10.1016/j.ibiod.2014.06.023

Garcés A, BerrioL, Ruiz S, Serna de León J, Builes A (2004) Ensilaje como fuente de alimentación para el ganado. Revista Lasallista de Investigación 1: 66–71. https://www.redalyc.org/articulo.oa?id=69511010

Garcia F (2006) Estructura Del Suelo y Nutrición Vegetal. Cultura Cientifica 4: 48–55. https://www.jdc.edu.co/revistas/index.php/Cult_cient/article/view/387

Garcia F, Gil P, Carrillo A (2009) Caracterización y calidad de un abono orgánico fermentado aof preparado con residuos del proceso de industrialización de la papa (Solanum tuberosum L). Logos C and T 1: 68–80. https://doi.org/10.22335/rlct.v1i1.35

Gavilanes I, Samaniego J, Idrovo J, Bustamante MA, Moral R, Paredes C (2016) Windrow composting as horticultural waste management strategy - A case study in Ecuador. Waste Manag 48: 127-134. https://doi.org/10.1016/j.wasman.2015.11.026

Golueke CG (1992) Bacteriology of composting. Biocycle 33: 55–57

Granada A, Prada Y (2015) Caracterización del lixiviado agroecológico a partir de residuos orgánicos de cultivos. RIAA 6: 169-182. https://doi.org/10.22490/21456453.1414

Hammer MJ, Hammer MJr (2003) Water and wastewater technology. Prentice-Hall of India, New Delhi

Hashemi H, Khodabakhshi A (2016) Complete treatment of compost leachate using integrated biological and membrane filtration processes. IJCCE 35: 81-87. https://doi.org/10.30492/IJCCE.2016.23589

Jokela J, Kettunen R, Sormunen K, Rintala J (2002) Biological nitrogen removal from municipal landfill leachate: Low-cost nitrification in biofilters and laboratory scale in-situ denitrification. Water Res 36: 4079–4087. https://doi.org/10.1016/S0043-1354(02)00129-X

Juma NG (1999) The pedosphere and its dynamics. A systems approach to soil science. Volume 1: Introduction to soil science and soil science resources. Salman Productions 315. https://doi.org/10.1016/s0016-7061(01)00014-3

Krogmann U, Woyczechowski H (2000) Selected characteristics of leachate, condensate and runoff released during composting of biogenic waste. Waste Manag Res 18: 235–248. https://doi.org/10.1007/s11157-018-9462-5

Kunhi Y, Kučerík J, Diehl D, Schaumann G (2012) Cation-mediated cross-linking in natural organic matter: A review. Rev Environ Sci Biotechnol 11: 41–54. https://doi.org/10.1007/s11157-011-9258-3

Li Z, Wang P, Menzies, Menzies NW, Kopittke PM (2018) Defining appropriate methods for studying toxicities of trace metals in nutrient solutions. Ecotoxicol Environ Saf 147: 872–880. https://doi.org/10.1016/j.ecoenv.2017.09.044

Lin CY (1993) Effect of heavy metals on acidogenesis in anaerobic digestion. Wat res 27: 147-152. https://doi.org/10.1016/0043-1354(93)90205-V

Llorente M, Lafuente F, Ruipérez C, Turrión M (2008) Uso de parametros edáficos como indicadores del efecto del uso del suelo en el páramo Calizo Castellano-Leonés. SECF 25: 273–279

Mishra S, Lata A, Tiwary D (2014) Studies of physico-chemical status of the ponds at Varanasi holy city under anthropogenic influences. IJERD 4: 261–268

Mokhtarani N, Bayatfard A, Mokhtarani B (2012) Full scale performance of compost’s leachate treatment by biological anaerobic reactors. Waste Manag Res 30: 524–529. https://doi.org/10.1177/0734242X11411014

Moreno J, Moral S (2008) Compostaje. Mundi-Prensa, Espain

Muñoz J (2000) Compostaje en Pescador, Cauca: Tecnología apropiada para el manejo de residuos orgánicos y su contribución a la solución de problemas medioambientales. Universidad Nacional de Colombia, Colombia

Pagans E, Barrena R, Font X, Sánchez A (2005) Ammonia emissions from the composting of different organic wastes. Dependency on process temperature. Chemosphere 62: 1534–42. https://doi.org/10.1016/j.chemosphere.2005.06.044

Peralta L, Juscamaita J, Meza V (2016) Obtaining and characterising an organic liquid fertilizer due to the treatment of dairy farm cattle manure using a lactic acid microbial consortium. Ecología Aplicada 15: 1–10. https://doi.org/10.21704/rea.v15i1.577

Perminova V, Kovalenko N, Kopplin S, Hatfield K, Hertkorn N, Belyaeva Y, Petrosyan S (2005) Design of quinonoid-enriched humic materials with enhanced redox properties. Environ. Sci Technol 39: 8518–8524. https://doi.org/10.1021/es050915j

Porta J, Lopez M, Roquero C (2003) Edafologia para la agricultura y el medio ambiente. Mundi-Prensa, Espain

Roig A, Lax A, Cegarra J, Costa F, Hernandez MT (1988). Cation exchange capacity as a parameter for measuring the humification degree of manures. Soil Sci 146: 311–316. https://doi.org/10.1097/00010694-198811000-00003

Roy D, Azaïs A, Benkaraache S, Drogui P, Tyagi R (2018) Composting leachate: Characterization, treatment, and future perspectives. Rev Environ Sci Biotechnol 17: 323–349. https://doi.org/10.1007/s11157-018-9462-5

Ryckeboer J, Mergaert J, Vaes K, Klammer S, De Clercq D, Coosemans J, Insam H, Swings J (2003) A survey of bacteria and fungi occurring during composting and self-heating processes. Ann Microbiol 53: 349–410. http://hdl.handle.net/1854/LU-218678

Salazar T (2014) Actividad microbiana en el proceso de compostaje aerobio de residuos sólidos orgánicos. RIU 3: 74–84. https://doi.org/10.17162/riu.v3i2.524

Samaniego J, Pedroza A (2013) Potential uses of volatile fatty acids in soil, water and air. Terra Latinoam 31: 155–163

Samaniego JJ, Pérez-Murcia MD, Bustamante MA, Paredes C, Pérez-Espinosa A, Gavilanes-Terán I, López M, Marhuenda-Egea FC, Brito H, Moral R (2017) Development of organic fertilizers from food market waste and urban gardening by composting in Ecuador. PLoS ONE 12: e0181621. https://doi.org/10.1371/ journal.pone.0181621

Sánchez O, Ospina DA, Montoya S (2017) Compost supplementation with nutrients and microorganisms in composting process. Waste Manag. 69: 136-153. https://doi.org/10.1016/j.wasman.2017.08.012

Schloss PD, Hay AG, Wilson DB, Gossett JM, Walker LP (2005) Quantifying bacterial population dynamics in compost using 16S rRNA gene probes. Appl Microbiol Biotechnol 66: 457–463. https://doi.org/10.1007/s00253-004-1727-y

Sotil F (2007) Dinámica poblacional de los microorganismos del grupo de coliforme, en el proceso de biodegradación aeróbica y anaeróbica de los abonos líquidos orgánicos biol y purin. Universidad Nacional Agraria La Molina, Perú

Stroppa N, Onelli E, Hejna M, Rossi N, Gagliardi A, Bini L, Baldi A, Moscatelli A (2020) Typha latifolia and Thelypteris palustris behavior in a pilot system for the refinement of livestock wastewaters: A case of study. Chemosphere 240: 124915. https://doi.org/10.1016/j.chemosphere.2019.124915

Superintendency of Public Domiciliary Services (2018) Final disposition of solid waste. National Report. https://www.superservicios.gov.co/sites/default/archivos/Publicaciones/Publicaciones/2020/Ene/informe_nacional_disposicion_final_2019. Accessed on 4 February 2020 (a). Comprehensive evaluation of providers servigenerales Tunja city S.A. E.S.P. IOP. https://www.superservicios.gov.co/sites/default/archivos/Acueducto%2C%20alcantarillado%20y%20aseo/Aseo/2018/Dic/evaluacion_integral_de_prestadores_servigenerales_ciudad_de_tunja_s.a._e.s.p. Accessed on 12 Novenber 2019 (b)

Torres D, Mendoza B, Marco L, Gómez C (2016) Calidad de abonos orgánicos empleados en la depresión de Quíbor-Venezuela bajo ambientes protegidos. Ciencia y Tecnología, 9: 1-10. https://doi.org/10.18779/cyt.v9i2.209

Turner L, Condron L, Richardson S, Peltzer D, Allison V (2007) Soil organic phosphorus transformations during pedogenesis. Ecosystems 10: 1166-1181. https://doi.org/10.1007/s10021-007-9086-z

United States-Canadian tables of feed composition (1982) Nutritional data for United States and Canadian feeds, Third revision. Washington, DC: The National Academies Press. https://doi.org/10.17226/1713

Wan H, Abdul K, Shazwani N, Sharil S, Mundher Z (2019) Spatial and temporal risk quotient based river assessment for water resources management. Environ. Pollut 248: 133–144. https://doi.org/10.1016/j.envpol.2019.02.011

Wang L, Lv D, Yan B, Zhang Y (2012) Fluorescence characteristics of dissolved organic matter during composting at low carbon/nitrogen ratios. Waste Manag Res 31: 203–211. https://doi.org/10.1177/0734242X12468195

Zahrim Y, Asis T, Hashim M.A, Al-Mizi TMA, Ravindra P (2015) A review on the empty fruit bunch composting: Life cycle analysis and the effect of amendment(s). Advances in Bioprocess Technology, pp 1-13. https://sci-hub.tw/10.1007/978-3-319-17915-5_1

Zahrim Y, Leong P, Ayisah S, Janaun J, Chong K, Cooke F, Haywood S (2016) Composting paper and grass clippings with anaerobically treated palm oil mill effluent. Int J Recycl Org Waste Agricult 5: 221–230. https://doi.org/10.1007/s40093-016-0131-9